Fuel filter for Daewoo Nexia with 8 and 16 valve engines are no different. The same spare part is put on all complete sets of the car. For the Nexia (N150), which was restyled in 2008, the same filter is used. In general, two fuel filters are installed on this car - the main one, which is also a fine filter, and the pump mesh filter, which is also a “diaper” (coarse filter).
The official supplier of original spare parts is Daewoo itself. But there is no exact information about the manufacturer, since this is not indicated on the filter housing itself, and the supplier does not disclose this. But, judging by the fact that some models of fuel filters from AMD are very similar in appearance to the original, and its filters are the most popular among analogues, it can be assumed that it is the manufacturer. Moreover, both AMD and Daewoo come from Korea.
Fuel filter for Daewoo Nexia - where is it located, features of choice
For all Nexias with 1.5 and 1.6 gasoline engines, the fuel filter is taken out separately, and is located under the bottom of the car, near the gas tank. The original article is 96130396, also found under the number 25055129. The price is 300 rubles. Made in a metal case, usually silver. Attached to metal tubes, so there is a thread at the ends of the filter nozzles. Under the same article, there is also a similar filter from General Motors, which is also the official supplier for Daewoo. In terms of characteristics, dimensions and design, it is identical to the original.
Original, 96130396
MANN-FILTER WK 612/2
The filter mesh of the pump differs depending on the year of installation. The old model (until 2002) had the article number 96183953. It did not have a plastic leg, and the diameter of the mounting hole was 22 mm. The most popular analogue is Amd FP163, prices - 50 rubles. The grid of the new sample (after 2002) has the article 96350078-2. It has a plastic leg-mount, and the hole diameter is 12 mm. The most popular substitute is Amd FP164, the price is 60 rubles.
The fuel module, in which the fuel pump is located, along with the grid, also differed depending on the year of manufacture of the car. Until 2002, they set 96350078, after - 96494976.
When and how to change the fuel filter on Nexia?
The manufacturer recommends replacing the fuel filter on Nexia every 20 thousand km. According to the experience of many drivers, it is best to do this 2 times more often - every 10 thousand km, since the quality of domestic fuel is not always good, and it gets clogged much more often. Moreover, its price is not very high. The mesh can simply be washed at each MOT.
In order to replace the main filter, the pressure in the fuel line must first be relieved. To do this, disconnect the battery, remove the terminals from the fuel pump (or simply pull out its fuse). Then connect the battery, start the engine, and wait until it stalls, having worked out all the remaining fuel in the system. To be sure, you can try to start the engine a couple of times. After that, you can disconnect the filter. For convenience, it is best to use a viewing hole, or jack it up.
Daewoo Nexia is a rather interesting model from the Korean auto industry. It does not differ in particular reliability, however, the car cannot be blamed for frequent breakdowns. At a minimum, the periodic replacement of Nexia consumables is a mandatory procedure for its owner. We will talk in more detail about one of these procedures in the article below. To be more precise, in today's material, our resource would like to take a closer look at the Daewoo Nexia fuel filter, diagnose its malfunctions and replace it.
Device
The Nexia fuel filter is an important element of the fuel system. In many ways, its importance is due to the fact that it filters the incoming fuel into the engine, and this already significantly extends the life of the latter.
On Daewoo Nexia, the fuel filter has a typical design for itself. It is a one-piece assembly into which are mounted:
- Coarse filter, which cleans the fuel from large contaminants.
- Fine filter that filters finer impurities.
The Nexia fuel filter is located in the area of \u200b\u200bthe gas tank of the car. To be more precise, the node in this model is located to the right of the gas tank and is attached to the rear longitudinal beam of the body. By design, the part is a metal cylinder of a non-separable format. According to the recommendations of the model manufacturers, the fuel filter needs to be replaced carry out every 30,000 kilometers run, and check it by blowing or in other ways - 6-8,000 kilometers.
Note! Given the disgusting quality of gasoline at Russian gas stations, it will be possible to get the real life of the Daewoo Nexia fuel filter by dividing the recommended mileage by two.
Troubleshooting
It is worth noting that it is quite difficult, inconvenient and not always accurate to track the life of the fuel filter to correctly determine the stability of the unit. As a result, when checking the health of the Daewoo Nexia fuel filter, the emphasis should be on the behavior of the car. In the case of "clogged" filter elements during the operation of the model, the following will be observed:
- problems with fuel consumption, of course, in a big way;
- unstable operation of the engine at idle;
- poor engine start;
- problems while driving - from insignificant tripling to pronounced twitching.
Important! Of course, the presence of such symptoms may also indicate a breakdown of other components of the car. However, as practice shows, when the symptoms described above appear, it is the fuel filter that should be checked first.
Such signs are worthy of special attention in the case when the Daewoo Nexia fuel filter has not changed for a long time. Do not forget that operating the machine with a "clogged" filter significantly reduces the life of its motor.
Node Replacement
Replacing the Daewoo Nexia fuel filter is a fairly simple procedure that any motorist with basic car repair skills can do. First of all, before starting a repair of this kind, you need to prepare. In the case of replacing the fuel filter, you will need the following tools:
- directly new filter;
- standard set of wrenches and sockets;
- different screwdrivers;
- pliers;
- rags;
- individual protection means.
Preparation done? So it's time to start renovating. In general, replacing the Nexia fuel filter is carried out in the following order:
- Set the machine to the place of repair. It is advisable to drive the car onto a flyover or raise it using a lift. Otherwise, there must be uninterrupted access to the bottom of the machine from its rear.
- Then depressurize the car's fuel system.
- After relieving pressure, you need to find the fuel filter on the bottom of the car at its rear.
- Node found? Now it remains only to dismantle its fasteners and carefully remove it, eliminating the resulting fuel smudges.
- Then a new part is installed in place of the old part. The car is brought to its original form and you can start its active operation.
Important! In the process of replacing the Daewoo Nexia fuel filter, you need to act carefully so as not to break other components of the machine. Otherwise, in addition to the fuel filter, you will have to change other elements of the car's design.
To relieve pressure in the fuel system, it is enough:
- disconnect the battery;
- remove the terminal from the fuel pump or remove the corresponding fuse in the mounting block;
- connect the battery;
- start the engine;
- wait until it dies down.
On this, perhaps, the most important information came to an end. We hope that the material presented above was useful for you and gave answers to your questions. Good luck on the roads and in the repair!
Video about replacing the Daewoo Nexia fuel filter:
The fuel filter is installed on the bottom of the car, on the starboard side, next to the fuel tank.
We carry out work on a viewing ditch or overpass.
The fuel in the engine power system is under pressure. Therefore, before servicing the fuel system, it is necessary to relieve fuel pressure. To do this, with the ignition off ...
... remove the fuel pump relay from the mounting block in the instrument panel.
We start the engine and let it idle until it stops due to running out of fuel in the system. Then we turn on the starter for 2-3 s. As a result, the pressure in the supply system will be relieved. 
.
Similarly, disconnect the fitting of the other fuel pipe. 
.
.
.
If necessary, replace the sealing rings with new ones.
The arrow on the fuel filter must point in the direction of fuel flow (toward the front of the vehicle).
When installing a filter... 
... we bait the fitting of the fuel pipes by hand ...
... and tighten them one by one. We wrap the bolt of the clamp. Having installed a new filter, we check the tightness of the connections with the engine running.
Our store delivers spare parts as agreed with the client and subject to availability. True, there is minimum order limit from which delivery possible - 2000 rub . This is due to purely economic reasons and we kindly ask you to be understanding and come for a nut or, for example, a filter yourself. Our address and ways to come to us on the page.
Our shipping cost
Cost of delivery of spare parts from our store in Moscow (within the Moscow Ring Road) - 500 rub. (Note: delivery is possible with an order amount of at least 2000 rubles), but at the same time, our store can not guarantee obligation delivery. Delivery service - "if possible".
But if the purchase amount has reached 5000 rubles, then delivery within Moscow will be FREE!
Delivery in the Moscow region is also possible, but by prior arrangement and at a "contractual" price.
Delivery time
The delivery time is agreed with the forwarder, who will definitely contact you shortly after you place your order.
Attention! Incorrect phone number, inaccurate or incomplete address may result in additional delay! Please carefully check your personal data when registering and placing an order. The confidentiality of your registration data is guaranteed.
Delivery is carried out daily from 10:00 to 19:00, delivery can also be made on Saturday, but by prior arrangement. There is no delivery on Sunday. Goods ordered by you on Saturday and Sunday are delivered on Monday or Tuesday.
Place of delivery
Delivery is carried out to the address indicated when placing the order. If you need to deliver the goods to a different address, you must provide the address to the manager who will contact you immediately after placing an order on the site.
Rules
Upon delivery, you will be given all the necessary documents for the purchase: invoice, cash receipt. When making a purchase for an organization, you will be given the original invoice and invoice, as well as an invoice in which you must put the seal of your organization and the signature of the responsible person. The price indicated in the documents sent to you by the courier is final, the courier does not have the right to adjust the price. Shipping costs are shown on the purchase documents as a separate line.
Attention! Please remember that all technical parameters, consumer properties, and, most importantly, the applicability of the purchased spare parts specifically to your car, you should check with our manager before purchasing the goods! The duties of the employees of the Delivery Service do not include consultations and comments on the applicability of spare parts and methods of their installation. Upon receipt of the ordered goods delivered to you, please check in the presence of the courier: the completeness of the delivered goods, the absence of damage to body parts, chips and cracks on the glass, the compliance of the delivered goods with the description on our website. If you do not declare claims regarding mechanical damage upon receipt of the goods, such claims will not be considered in the future. In case of questions, wishes and claims, please contact us at the following coordinates.
According to the regulations, the fuel filter in Daewoo Nexia cars must be replaced every 40 thousand kilometers, or after every two years of operation. But given the quality of our fuel, it can be replaced much more frequently. To select a fuel filter for Nexia, use the table that lists filter manufacturers and model catalog numbers.
| MANUFACTURER | VENDOR CODE |
| ORIGINAL | |
| DAEWOO | 25055129 |
| ANALOGUES | |
| ASAM | 30523 |
| MAPCO | 62512 |
| FORD | 1137438 |
| KNECHT | 25055129 |
| DAEWOO | 96130396 |
| GM | 96130396 |
| JPN | 96130396 |
| O.E. | 96130396 |
| ONNURI | 96130396 |
| Bosch | 986450119 |
| PROFIT | 1530-2903 |
| ASHIKA | 30-03-393 |
| TSN | 931AL |
| PMC | 96130396_PMC |
| DENCKERMANN | A110016 |
| BLUE PRINT | ADG02302 |
| AMD | AMDFF29 |
| PREMIUM | B30001PR |
| JAPAN CARS | B30008D |
| TOKO CARS | BK3-001TOKO |
| AMC | DF7740 |
| MECAFILTER | ELE6019 |
| JAPANPARTS | FC-393S |
| FORTECH | FF001 |
| AMP | FF1101 |
| GOODWILL | FG601 |
| J.S. ASAKASHI | FS481J |
| FIAAM | FT5294 |
| KAP | G03FULSD00144 |
| INTERPARTS | IPF-D001 |
| NIPPARTS | J1330900 |
| KEMP | KE4203 |
| LYNX | LF1117 |
| MANN | MANN WK 612/2 |
| PARTS-MALL | PCC-002 |
| FILTRON | PP859 |
| BUGUS | QIN3727 |
| ALCO | SP-2083 |
| SCT | ST 329 |
| WIX | WF8064 |
Instructions for replacing the fuel filter on Daewoo Nexia + photo report
1. The fuel filter in Nexia is located under the bottom to the right of the gas tank, so the car will need to be driven onto an overpass, pit, or simply jacked up.
Replacing the fuel filter Daewoo Nexia 2. Now, in order not to be doused with gasoline during the process, you need to relieve pressure in the fuel system. To do this, open the mounting block, find the fuel pump fuse marked F7 and remove it from the seat.
3. We start the engine and let it run for a few seconds. The fuel pump will not work and the pressure in the system will drop.
4. Find the fuel filter. With keys 21 and 16, we unscrew the fuel line fitting from the filter, first on one side, then on the other. At this time, a small amount of gasoline may leak out.
5. Using a 13 key, unscrew the clamp bolt that secures the filter.
